Mazda 3 Service Manual: General Procedures (Steering)

Mazda 3 Service Manual: General Procedures (Steering)

Wheel and Tire Installation

1. When installing the wheels and tires, tighten the wheel nuts in a criss-cross pattern to the following tightening torque.


  • Tightening torque
  • 88—118 N·m {9.0—12 kgf·m, 65—87 ft·lbf}

Connector Disconnection

1. Disconnect the negative battery cable before performing any work that requires handling of connectors..

Suspension Links Removal/Installation

1. For the joint sections with rubber bushings, raise the vehicle using a lift, and then temporarily tighten the installation bolts and nuts. Lower the vehicle to the ground and tighten them completely with the specified torque.

Power Steering Related Parts Installation

1. If any power steering fluid line has been disconnected, perform the following after installation of the power steering components..

  • Power steering fluid amount inspection

  • Power steering fluid leakage inspection

  • Air bleeding

Electro Hydraulic Power Assist Steering (EHPAS) Related Parts

CAUTION:

  • If the configuration procedure is not completed, the EHPAS will not operate properly and it might cause an unexpected accident. Therefore, when replacing or removing the electric power steering oil pump component, make sure to perform the configuration procedure to ensure the proper EHPAS operation.

1. Make sure that there are no DTCs in the EHPAS memory after working on EHPAS related parts. If there are any codes in the memory, clear them.

2. When replacing or removing the electric power steering oil pump component, perform the configuration procedures..

Precaution
Intermittent Concern Troubleshooting Vibration method If a malfunction occurs or becomes worse while driving on a rough road or when the engine is vibrating, perform the following steps. ...
Other materials:

Customer Assistance (Mexico)
Your complete and permanent satisfaction is our business. We are here to serve you. All Authorized Mazda Dealers have the knowledge and the tools to keep your Mazda vehicle in top condition. If you have any questions or recommendations for improvement regarding the service of your Mazda ...

Drive Shaft Inspection
1. Inspect the connections for any looseness. If there is any malfunction, tighten or replace the applicable part. 2. Inspect the dust boot for damage and cracks. If there is any malfunction, replace the applicable part. 3. Move the spline and joint up and down, left ...

Front Stabilizer Control Link Inspection
1. Remove the front stabilizer control link from the vehicle.. (See FRONT STABILIZER REMOVAL/INSTALLATION [MZR 2.3 DISI Turbo] 2. Inspect for bending or damage. If there is any malfunction, replace the stabilizer control link. 3.

Related news

  • Mazda 3 Service Manual: Variable Valve Timing Actuator Inspection Mzr 2.3 Disi Turbo
  • Nissan Rogue Service Manual: Front wiper does not operate
  • Hyundai Elantra: Power Door Lock Actuators. Repair procedures
  • Mazda 3 Service Manual: Front Shock Absorber And Coil Spring DisassemblyAssembly
  • Subaru Legacy: Canada-spec. models

  • Mazda 3 Service Manual: General Procedures (Steering)

    Mazda 3 Service Manual: General Procedures (Steering)

    Mazda 3 Service Manual: General Procedures (Steering)

    Mazda 3 Service Manual: General Procedures (Steering)

    Mazda 3 Service Manual: General Procedures (Steering)

    Mazda 3 Service Manual: General Procedures (Steering)

    Mazda 3 Service Manual: General Procedures (Steering)

    Mazda 3 Service Manual: General Procedures (Steering)

    Mazda 3 Service Manual: General Procedures (Steering)

    Mazda 3 Service Manual: General Procedures (Steering)

    Mazda 3 Service Manual: General Procedures (Steering)

    Mazda 3 Service Manual: General Procedures (Steering)

    Mazda 3 Service Manual: General Procedures (Steering)

    Mazda 3 Service Manual: General Procedures (Steering)

    Mazda 3 Service Manual: General Procedures (Steering)

    Mazda 3 Service Manual: General Procedures (Steering)

    Mazda 3 Service Manual: General Procedures (Steering)

    Mazda 3 Service Manual: General Procedures (Steering)

    Mazda 3 Service Manual: General Procedures (Steering)

    Mazda 3 Service Manual: General Procedures (Steering)

    Mazda 3 Service Manual: General Procedures (Steering)

    Mazda 3 Service Manual: General Procedures (Steering)

    Mazda 3 Service Manual: General Procedures (Steering)

    Mazda 3 Service Manual: General Procedures (Steering)

    Mazda 3 Service Manual: General Procedures (Steering)

    Mazda 3 Service Manual: General Procedures (Steering)

    Mazda 3 Service Manual: General Procedures (Steering)

    Mazda 3 Service Manual: General Procedures (Steering)

    Mazda 3 Service Manual: General Procedures (Steering)

    Mazda 3 Service Manual: General Procedures (Steering)