Nissan Rogue Service Manual: Exhaust manifold and three waycatalyst

Nissan Rogue Service Manual: Exhaust manifold and three waycatalyst

Nissan Rogue Service Manual: Exhaust manifold and three way catalyst

Exploded View

Exploded View

  1. Cylinder head
  2. Exhaust manifold and three way catalyst gasket
  3.  Exhaust manifold cover (upper)
  4.  Exhaust manifold and three way catalyst
  5.  Exhaust manifold cover (lower front)
  6.  Exhaust manifold cover (lower rear)
  7.  Air fuel ratio (A/F) sensor 1

Removal and Installation

REMOVAL

  1.  Disconnect battery negative terminal.
  2.  Remove A/C line bracket bolt (A).

Removal

  1. Remove engine under cover. Refer to EXT-37, "ENGINE UNDER COVER : Removal and Installation".
  2.  Remove the oil level gauge and oil level gauge guide. Refer to EM-92, "Exploded View".
  3.  Remove harness ground wire bolt from generator bracket.
  4.  Disconnect harness connector from air fuel ratio (A/F) sensor 1.
  5. Remove the air fuel ratio (A/F) sensor 1 (1) using Tool (A), (if necessary).

Tool number : KV10117100 (J-36471-A)

CAUTION:

  •  Be careful not to damage air fuel ratio (A/F) sensor.
  •  Discard any air fuel ratio (A/F) sensor which has been dropped from a height of more than 0.5 m (19.7 in) onto a hard surface such as a concrete floor; replace with a new one.

Removal and Installation

  1. Detach front exhaust tube from exhaust manifold and three way catalyst. Discard the gasket. Refer to EM-29, "Exploded View".
  2.  Remove the exhaust manifold cover (upper).
  3. Loosen the exhaust manifold and three way catalyst nuts in the reverse order as shown.

Removal and Installation

  1. Remove exhaust manifold and three way catalyst.
  2.  Remove the exhaust manifold cover (lower front) (if necessary).
  3. . Remove the exhaust manifold cover (lower rear) (if necessary).

INSPECTION AFTER REMOVAL

Surface Distortion

  •  Check the flatness of exhaust manifold and three way catalyst using suitable tools (A/B).

    NOTE: Place the suitable tool (A) diagonally and measure in several locations.

Limit : 0.3 mm (0.012 in)

Inspection after removal

INSTALLATION

Exhaust Manifold

Installation is in the reverse order of removal.

CAUTION:

  •  Do not reuse an exhaust manifold cover which has been dropped.
  •  Be careful not to deform exhaust manifold covers.
  1.  Install studs in cylinder head studs and exhaust manifold and three way catalyst (if removed). Then tighten to specification.

    CAUTION: Do not reuse cylinder head or exhaust manifold studs.

  2. Install the exhaust manifold and exhaust manifold and three way catalyst gasket. Then tighten the nuts to specification in the numerical order shown.

    CAUTION: Do not reuse exhaust manifold and three way catalyst gasket.

Exhaust Manifold

  1. Install the air fuel ratio (A/F) sensor 1 (1) using Tool (A) and tighten to specification.

Tool number : KV10117100 (J-36471-A)

CAUTION:

  •  Be careful not to damage air fuel ratio (A/F) sensor.
  •  Discard any air fuel ratio (A/F) sensor which has been dropped from a height of more than 0.5 m (19.7 in) onto a hard surface such as a concrete floor; replace with a new one.
  •  Do not over-tighten the air fuel ratio (A/F) sensor 1. Doing so may cause damage to the air fuel ratio (A/F) sensor 1, resulting in a malfunction and the MIL coming on.

Exhaust Manifold

Intake manifold
Exploded View Intake manifold  Intake manifold gasket  Electirc throttle control actuator O-ring  Electric throttle control actuator Removal and Installation REMOVAL ...
Oil pan and oil strainer
Exploded View Oil pan, upper  Oil filter  Front cover  O-ring  Oil strainer  Oil pan, lower  Washer Drain plug O-ring  Oil level gaug ...
Other materials:

Engine compartment
CAUTIONNever use a fuse of a higher or lower amperage rating than specified on the fuse box cover. This could damage the electrical system or cause a fire. Two types of fuses are used. Type A is used in the fuse boxes in the engine compartment.

Related news

  • Toyota RAV4 Service Manual: Vehicle speed sensor A
  • Toyota Sienna 2010-2018 Owners Manual: Taking out the spare tire
  • Toyota Sienna Service Manual: GPS Antenna Error GPS Antenna Power Source Error
  • Chrysler 200: Onboard Diagnostic System — OBD II
  • Toyota RAV4 Service Manual: General maintenance (200601- )

  • Nissan Rogue Service Manual: Exhaust manifold and three waycatalyst

    Nissan Rogue Service Manual: Exhaust manifold and three waycatalyst

    Nissan Rogue Service Manual: Exhaust manifold and three waycatalyst

    Nissan Rogue Service Manual: Exhaust manifold and three waycatalyst

    Nissan Rogue Service Manual: Exhaust manifold and three waycatalyst

    Nissan Rogue Service Manual: Exhaust manifold and three waycatalyst

    Nissan Rogue Service Manual: Exhaust manifold and three waycatalyst

    Nissan Rogue Service Manual: Exhaust manifold and three waycatalyst

    Nissan Rogue Service Manual: Exhaust manifold and three waycatalyst

    Nissan Rogue Service Manual: Exhaust manifold and three waycatalyst

    Nissan Rogue Service Manual: Exhaust manifold and three waycatalyst

    Nissan Rogue Service Manual: Exhaust manifold and three waycatalyst

    Nissan Rogue Service Manual: Exhaust manifold and three waycatalyst

    Nissan Rogue Service Manual: Exhaust manifold and three waycatalyst

    Nissan Rogue Service Manual: Exhaust manifold and three waycatalyst

    Nissan Rogue Service Manual: Exhaust manifold and three waycatalyst

    Nissan Rogue Service Manual: Exhaust manifold and three waycatalyst

    Nissan Rogue Service Manual: Exhaust manifold and three waycatalyst

    Nissan Rogue Service Manual: Exhaust manifold and three waycatalyst

    Nissan Rogue Service Manual: Exhaust manifold and three waycatalyst

    Nissan Rogue Service Manual: Exhaust manifold and three waycatalyst

    Nissan Rogue Service Manual: Exhaust manifold and three waycatalyst

    Nissan Rogue Service Manual: Exhaust manifold and three waycatalyst

    Nissan Rogue Service Manual: Exhaust manifold and three waycatalyst

    Nissan Rogue Service Manual: Exhaust manifold and three waycatalyst

    Nissan Rogue Service Manual: Exhaust manifold and three waycatalyst

    Nissan Rogue Service Manual: Exhaust manifold and three waycatalyst