Toyota RAV4 Service Manual: Installation (200601- )

Toyota RAV4 Service Manual: Installation (2006/01- )

  1. Install front drive shaft assembly lh

Toyota RAV4. Install front drive shaft assembly lh


  1. Coat the spline of the inboard joint shaft with gear oil.
  2. Align the shaft splines and tap in the drive shaft with a brass bar and hammer.

Notice:

  • Set the snap ring with the opening side facing downwards.
  • Be careful not to damage the oil seal, boot and dust cover.
  1. Install front drive shaft assembly rh

Toyota RAV4. Install front drive shaft assembly rh


  1. Coat the spline of the inboard joint shaft with gear oil.
  2. Align the shaft splines and securely insert the drive shaft.
  3. Install the 2 bearing bracket bolts.

Torque: 63.7 N*m (650 kgf*cm, 47 ft.*Lbf)

Notice:

Do not damage the oil seal, boot and dust cover.

  1. Connect steering knuckle with axle hub lh

Toyota RAV4. Connect steering knuckle with axle hub lh


  1. Align the shaft splines in the drive shaft to the steering knuckle with axle hub, and connect the steering knuckle with axle hub.
  1. Connect steering knuckle with axle hub rh

Hint:

Use the same procedures described for the lh side.

  1. Connect front suspension no. 1 Lower arm sub-assembly lh (see page sp-24)
  2. Connect front suspension no. 1 Lower arm sub-assembly rh

Hint:

Use the same procedures described for the lh side.

  1. Install front stabilizer link assembly lh (see page sp-31)
  2. Install front stabilizer link assembly rh

Hint:

Use the same procedures described for the lh side.

  1. Connect tie rod end sub-assembly lh (see page ps-45)
  2. Connect tie rod end sub-assembly rh

Hint:

Use the same procedures described for the lh side.

  1. Connect front speed sensor lh
  1. Connect the speed sensor (see page bc-193).
  1. Install front speed sensor rh

Hint:

Use the same procedures described for the lh side.

  1. Install front axle hub nut (see page ah-11)
  2. Install front wheel torque: 103 n*m (1,050 kgf*cm, 76 ft.*Lbf)
  3. Add automatic transaxle fluid
  1. Add automatic transaxle fluid for u140f (see page ax-152).
  2. Add automatic transaxle fluid for u241e (see page ax-151).
  3. Add automatic transaxle fluid for u151e (see page ax-177).
  1. Check for automatic transaxle oil leakage
  2. Inspect and adjust front wheel alignment
  1. Inspect and adjust the front wheel alignment (see page sp-3).
Other materials:

Installation (2005/11-2006/01)
Install front drive shaft assembly lh Coat the spline of the inboard joint shaft with gear oil. Using a brass bar and hammer, align the shaft splines in the drive shaft. Notice: Set the snap ring with the opening side facing downwards. Be careful not to damage the oil s ...

Checking monitor status
Perform monitor drive pattern Connect the intelligent tester to the dlc3. Turn the ignition switch and the tester on. Clear the dtcs (see page es-35). Run the vehicle in accordance with the applicable drive pattern described in readiness monitor drive pattern (see page es-19). Do ...

Removal and installation of engine intake parts
If any metal particles enter inlet system parts, they may damage the engine. When removing and installing inlet system parts, cover the openings of the removed parts and engine openings.

Related news

  • Mercedes-Benz E-Class: The first 1000 miles (1500 km)
  • Scan tuning (SCAN)
  • Nissan Altima: Fuses
  • Hyundai Elantra: Electronic stability control (ESC) (If equipped)
  • Mazda 3 Service Manual: Water Pump RemovalInstallation Mzr 2.0, Mzr 2.5

  • Toyota RAV4 Service Manual: Installation (200601- )

    Toyota RAV4 Service Manual: Installation (200601- )

    Toyota RAV4 Service Manual: Installation (200601- )

    Toyota RAV4 Service Manual: Installation (200601- )

    Toyota RAV4 Service Manual: Installation (200601- )

    Toyota RAV4 Service Manual: Installation (200601- )

    Toyota RAV4 Service Manual: Installation (200601- )

    Toyota RAV4 Service Manual: Installation (200601- )

    Toyota RAV4 Service Manual: Installation (200601- )

    Toyota RAV4 Service Manual: Installation (200601- )

    Toyota RAV4 Service Manual: Installation (200601- )

    Toyota RAV4 Service Manual: Installation (200601- )

    Toyota RAV4 Service Manual: Installation (200601- )

    Toyota RAV4 Service Manual: Installation (200601- )

    Toyota RAV4 Service Manual: Installation (200601- )

    Toyota RAV4 Service Manual: Installation (200601- )

    Toyota RAV4 Service Manual: Installation (200601- )

    Toyota RAV4 Service Manual: Installation (200601- )

    Toyota RAV4 Service Manual: Installation (200601- )

    Toyota RAV4 Service Manual: Installation (200601- )